Question about Polaris ATV

Open Question

How do I REMOVE THE FLYWHEEL ON MY 2009 POLARIS SPORTSMAN 90

Posted by on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad
  • 5 Answers

SOURCE: I have a Polaris 700 Sportsman. It runs but will

I would say the voltage regulator since it is not charging

Posted on Jun 28, 2009

Ad
  • 1 Answer

SOURCE: 2001 Polaris sportsman 500 magnum 4x4, speedo dont work

I'm not sure but it might be the sensor on the right front wheel disk

Posted on Sep 05, 2009

  • 93 Answers

SOURCE: Polaris Sportsman 90 - stalls

Is the choke in the on position? Have you warmed it up enough?

Posted on Sep 11, 2009

  • 1 Answer

SOURCE: how do i remove rear axle

how do i get the back cv axle out of my 01 polaris sportsman 500 h.o

Posted on Apr 17, 2010

  • 1 Answer

SOURCE: Service manual for a 2006 500 Polaris Sportsman HO

I have a 2006 Sportstman 500HO ATV, EFI. Sometimes it will run 100% correct, other times it will start, idle fine but then when giving it throttle will will start to surge almost like it's hitting a rev limited. Sometimes it will backfire and stall. I already replaced fuel filter, flushed the fuel lines and gave it fresh gas and installed a new spark plug, but no good. I also checked the throttle switch and it's not making contact to stall it. I download the service manaul and tested each sensor and they tested fine which is probablt why I get no check engine light.
This ATV is mainly used to plow snow in my driveway, no salt. It's used around my property but very lightly. It's still as clean as it was when I bought it and it doesn't have but about 40 hours on it.
Polaris 500 HO EFI 4x4 ATV: Vin# 4XAMH50A56B707664 purchased 6-8-2006

gtopercy@comcast.net

Posted on Jul 15, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Polaris Sportsman 90 it bogs down/stalls. new carb. it will rev up in neutral. however when you put it in gear bike will only run for a few minutes and then stall or quit running. will restart .


Check the Flywheel key. It should be locked under the pull cord, where the stator is located. I will be a small piece of metal that slides into the spline from the engine and the stator. If it is worn the stator will rotate off the spline and the timing will be off, she won't start and if she does will be really rough and backfire, sputter and have power loss.

Dec 08, 2016 | Polaris 2006 Sportsman 90

1 Answer

I have a 2009 Polaris Sportsman 500EFI 4 wheeler. Recently, the number 1200 started flashing under the speedo. What does this indicate?


that sounds like your clock. engine codes don't go that high.and if it was your clock you must of lost 12 volt power at some point.

Jan 29, 2016 | Polaris 2009 Sportsman 500 EFI Touring

1 Answer

I have a 2009 Polaris 500 Sportsman. A number 1200 flashes on the Speedometer. What does that indicate?


that sounds like your clock you must of lost 12 volt connection at some point engine codes dont go that high

Jan 27, 2016 | Polaris 2009 Sportsman 500 EFI

1 Answer

Wont go in 2 wheel drive but switch works light come on dash ?


2004 Sportsman 700 AWD not working..... - Polaris ATV Forum

www.polarisatvforums.com > ... > ATV Repair and Maintenance
Feb 18, 2013 - Go Back ยท Polaris ATV Forum > Polaris ATV Technical Discussions > ATV ... AWD wont engage. 2. The instrument / speedo works. 3. The AWD switch is ...Polaris ATV Junkie! .... four wheel drive not working polaris sportsman. Won't go into 4 wheel drive
Feb 1, 2013
4 wheel drive not working
Nov 13, 2011
2004 700, 4WD engages by itself
Oct 28, 2011
4wd is stuck on
Dec 3, 2009
More results from www.polarisatvforums.c

Nov 29, 2015 | Polaris 2004 Sportsman 700 Twin

1 Answer

Sportsman 90 idles wont rev


Replace spark plug (gap correctly),Drain all fuel, replace fuel filter, replenish tank with fresh fuel, do a thorough readjustment of the carb settings (last resort - remove and rebuild carb)

Feb 17, 2015 | Polaris 2008 Sportsman 90

1 Answer

2009 polaris 850 sportsman, reverse will not work.


put some grease in the tranny, and while your at it check th back diff too, by just loosening the pumpkin bolt and sticking your finger in there to see if there is enough 75/90, if not just ADD TO THE PUMPKIN till it reaches the top of the bolt hole while the unit is sitting on its 4 wheels it should just be spilling out at the threads put bolt back in and hand tighten then snug but not too tight, tht should do it.

Mar 31, 2014 | Polaris 2009 Sportsman 850 EFI XP With EPS

Not finding what you are looking for?
Polaris ATV Logo

Related Topics:

343 people viewed this question

Ask a Question

Usually answered in minutes!

Top Polaris ATVs Experts

john h

Level 3 Expert

17286 Answers

Matt Olenzek
Matt Olenzek

Level 2 Expert

297 Answers

Wade Mobley
Wade Mobley

Level 3 Expert

513 Answers

Are you a Polaris ATV Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...