Question about Polaris ATV

Open Question

Sportsman 700 won't start

Polaris 2002 Sportsman 700 won't start when you turn the key. Battery is good. No prior problems. Turn the key and you hear a click. Sometimes you will hear something that sounds like a gear trying to catch. The instrument panel comes on when the key is turned. Please help.

Posted by on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 1 Answer

SOURCE: 2002 Polaris Sportsman 700: AWD Not Engaging

ok i have a 335 that had a similiar problem 4 wheel drive would not engage and speedometer acted like it was a tach when started in an idol..... i replaced the battery and believe the condition was caused by low voltage if your battery is is not very good your machine wont generate enough voltage for your 4 wheel drive to engage....try it maybe this will help...

Posted on Aug 09, 2009

  • 1 Answer

SOURCE: 2005 Polaris 700 sportsman 4x4 gets warm, looses power?

My Sportsman runs bad when heated up, but if you add fuel it runs fine again. I had a pick up that had an internal fuel pump like our Sportsman's and it did the exact same thing. It turned out being the fuel pump was worn out due to a plugged fuel filter. Forcing the pump to fail prematurely. I found I had bad fuel in my Sportsman and am going to replace the filter and the fuel pump. I also checked my plugs, MAF sensor, and Air filter, they were fine.

Posted on Sep 16, 2009

  • 1 Answer

SOURCE: overheating polaris sportsman 700

you probly need a new heat sensor, its located on the bottom right of your rad, i had the same problem with my 700 the fan only worked when it was already over heating, i cut the wires flush at the sensor drilled a hole above the key switch and mounted a toggle switch, no more over heating,

Posted on Oct 24, 2009

  • 1 Answer

SOURCE: 03 Polaris sportsman 700 4x4 will not Disengage

I KNOW THAT IF YOU HAVENT CHANGED THE HUB OIL IN A WHILE THAT IT GETS DIRTY AND GETS STUCK IN 4-WHEEL

Posted on Jan 25, 2010

  • 1 Answer

SOURCE: Service manual for a 2006 500 Polaris Sportsman HO

I have a 2006 Sportstman 500HO ATV, EFI. Sometimes it will run 100% correct, other times it will start, idle fine but then when giving it throttle will will start to surge almost like it's hitting a rev limited. Sometimes it will backfire and stall. I already replaced fuel filter, flushed the fuel lines and gave it fresh gas and installed a new spark plug, but no good. I also checked the throttle switch and it's not making contact to stall it. I download the service manaul and tested each sensor and they tested fine which is probablt why I get no check engine light.
This ATV is mainly used to plow snow in my driveway, no salt. It's used around my property but very lightly. It's still as clean as it was when I bought it and it doesn't have but about 40 hours on it.
Polaris 500 HO EFI 4x4 ATV: Vin# 4XAMH50A56B707664 purchased 6-8-2006

gtopercy@comcast.net

Posted on Jul 15, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

Fuel gauge flashes need fuel most of the time


Gary, Faulty fuel pump sending unit. Most of the forums I checked say this a big problem with Polaris, most say the pump and sending unit have to be bought as a assembly.
Check the attached links,instruction and guides, Good luck
"I hope this helped you out, if so let me know by pressing the helpful button. Check out some of my other posts if you need more tips and info."

08 800 sportsman fuel gauge not reading correctly

Guide to Servicing the Fuel Pump Gauge Regulator 2006 Sportsman 700 EFI

Polaris Sportsman 700 fuel gauge fix

Inaccurate Fuel Gauge Fix Flashing Fuel Indicator

Mar 31, 2016 | Polaris 2008 Sportsman 500 EFI X2

1 Answer

New battery, new solenoid.... turn key display lights come on but will not ignite. Do not get a click or anything.


Sounds like your new battery was not charged when it was sold to you. Put it on a 12 volt charger for 6 hours.

Feb 06, 2016 | Polaris 2004 Sportsman 700 Twin

1 Answer

Will a 2002 Polaris sportsman ho 500motor and all accessories fit onto a 2002 polaris 700 sportsman frame


They're not compatible - officially. May just depend on how willing you are to make it work. Either way - the 2002 Polaris Sportsman 700 shows as only being compatible with the 2002, 2003 and 2004 Sportsman 700 & 600 - both models both years. Now - they look pretty close, but if you cross check (Looks like Polaris did a mid-model swap or something). There are (2) frames listed for the 2002 Polaris Sportsman 500 -
First Option - built before 9/3/01 Part # 1013325-067
01 - 02 SPORTSMAN 400
01 - 02 SPORTSMAN 500
01 WORKER 500

SECOND OPTION/AFTER 9.3.01 1013729-067
- JUST THE 02 SPORTSMAN 500

I attached the link to the schematic for you to see. To do a cross reference, copy the part number instead of pressing it (clicking on the part # a lot of the times doesn't show you full compatiblity). Then on the top banner, click OEM Genuine Parts, Polaris, ATV - there will be a parts search bar on the right hand side - paste your part # there and click search. If there are group compatibilities that they've added over time you'll see more than one 'where used' - just click on each one if you have to, but you'll see all compatible models.

copy part number
go back to page one of OEM Polaris parts
paste in search box
click on 'where used' in red to the right of the listing. If more than one - notate each as you go - but you'll see everywhere it was used. I've got a frame from a 2000 Polaris Expedition 425 4x4 with swingarm attached - I'd sell basically for shipping cost on ebay - if you're close to North Florida and in the area - I'd give it to you for $50, FYI. Here's a link to the listing and pictures in there - looks like a copy of the sportsman. If you get to zooming in on both and this looks like a match let me know. And a lot of parts were interchangeable for years on top of years from some parts - check out my ebay store (It's not finished but a lot of parts are on their) subscribe as a follower - and I'll give you 30% off your first order as a Thank You. I price to sell and compete, by the way - free shipping on almost everything - and all you have to do is shop around on there to see where I stand. 17 South Industries, LLC - I could use some help just gettting the name out there and word of mouth. All the best - Good Luck

2002 Polaris SPORTSMAN 500 ALL OPTIONS A02CH50 Parts

eBay Store 17 SOUTH INDUSTRIES:

http://stores.ebay.com/17-SOUTH-INDUSTRIES

will-2002-polaris-sportsman-ho-500motor-j4wo0haptr1gssv4itpholao-4-0.png

Dec 25, 2015 | ATVs

1 Answer

Wont go in 2 wheel drive but switch works light come on dash ?


2004 Sportsman 700 AWD not working..... - Polaris ATV Forum

www.polarisatvforums.com > ... > ATV Repair and Maintenance
Feb 18, 2013 - Go Back ยท Polaris ATV Forum > Polaris ATV Technical Discussions > ATV ... AWD wont engage. 2. The instrument / speedo works. 3. The AWD switch is ...Polaris ATV Junkie! .... four wheel drive not working polaris sportsman. Won't go into 4 wheel drive
Feb 1, 2013
4 wheel drive not working
Nov 13, 2011
2004 700, 4WD engages by itself
Oct 28, 2011
4wd is stuck on
Dec 3, 2009
More results from www.polarisatvforums.c

Nov 29, 2015 | Polaris 2004 Sportsman 700 Twin

1 Answer

How do I hook up the choke cable on a 2006 Polaris Sportsman 700?


Did your machine not come with one from the dealer? Is your machine fuel injected?

Nov 09, 2014 | Polaris 2006 Sportsman 700 Twin EFI

1 Answer

Does a bad battery have any bearing on the efi of a Polaris Sportsman 700 2004?


If motor has to constantly charge a battery while running, it could use a bit more fuel.

Oct 14, 2014 | Polaris 2004 Sportsman 700 Twin

1 Answer

No power


check the main fuse on + line close to the battery or under the seat at the rear. sounds like thats your problem.

Jun 13, 2013 | Polaris 2006 Sportsman 500 HO

Not finding what you are looking for?
Polaris ATV Logo

Related Topics:

383 people viewed this question

Ask a Question

Usually answered in minutes!

Top Polaris ATVs Experts

john h

Level 3 Expert

11057 Answers

Matt Olenzek
Matt Olenzek

Level 2 Expert

293 Answers

yadayada
yadayada

Level 3 Expert

75066 Answers

Are you a Polaris ATV Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...