Question about Polaris ATV

3 Answers

Polaris Xpress 300. Won't start, backfires through carb sometimes

Changed spark plug. Gas is backing up into the airfilter box. backfires sometimes. Has suction going into the carb when turning over and pressure coming out of the exhaust when turning over.
Any idea what is wrong. Help Please.

Posted by on

Ad

3 Answers

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that has over 10 points.

    Mayor:

    An expert whose answer got voted for 2 times.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 5 Answers

Sounds like maybe the needle and seat in the carb letting gas through.

Posted on Jun 28, 2009

Ad
  • Level 1:

    An expert who has achieved level 1.

    New Friend:

    An expert that has 1 follower.

  • Contributor
  • 1 Answer

I have seen this problem of fuel draining into air box and down into crank case. then it wont run past idle and backfires. TAKE MY ADVISE do not keep running or trying to run without checking to be sure there is no gas in your crank case,it will trash engine. As for the problem...it is either the needle,the float or the rubber ring that the needle pushes against to stop fuel flow when bowl is full.If it is the seat or ( rubber ring)In some carbs it cannot be replaced. This means go buy a new carb...they are not cheap but cheaper than motor and carb understand. Replace float,needle,seat if possible or carb if not possible then drain oil in crank replace oil ,oil filter wipe out air box let air filter dry put it all together and go ride!Hope this helps.

Posted on Jan 02, 2013

Ad
  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that has over 10 points.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 13 Answers

The needle vavle in the carb might be sticking. Also check the throttle cable itself it may have some sand or dirt in it. move the throttle back and forth of it sounds like there is any grit in it try spraying some silicon spray or wd-40 in it.

Posted on Feb 02, 2012

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

89 Polaris Ranger500 6x6 side by sideis coughing,spitting and backfireing thew carb.whats the fix


I would start by pulling and cleaning the carb, air filter and spark plug. Usually the cause starts with dirty air filters that gets the carbs dirty which then cause the polaris to run rich and the plug will start to foul. The unburnt fuel ignites at the wrong time and back fires. A less likely problem would be out of timing.

Feb 13, 2017 | Polaris ATV

2 Answers

1989 polarus Ranger500 6x6 is backfiring thew carb.


Fouled plugs or leaking spark plug cables.

Feb 13, 2017 | Polaris ATV

2 Answers

My four wheeler gets spark and gas to the carb but wont start what else could it be?


Carb could be dirty, float stuck or choke stuck. Pull plugs, crank engine and see if you are getting raw gas in the cylinder(s). If you don't get gas to the cylinders, you won't start. You also could have a flooded carburetor.

Jun 15, 2015 | Polaris 2004 Trail Blazer 250

1 Answer

She got gas and prark won.t start only backfire


Remove and clean the plug, sounds like it is fouled.

Jan 31, 2015 | Polaris 2007 Sportsman 450

1 Answer

Won`t start and backfires with throttle or choke


try cleaning carb and running ethanol free fuel with injector/carb cleaner in it

Dec 22, 2013 | Yamaha Kodiak 400 Auto 4x4 ATVs

1 Answer

Polaris 325 magnum spark plug change


The spark plug is on the left side (shifter) of the head,,..?/ this is August.. if the atv has been sitting the carb may need a qualified professional to clean it again.. Replace the spark plug before you squirt anything in the engine...

Jul 27, 2017 | Polaris ATV

1 Answer

I HAVE A 1999 POLARIS 335 SPORTSMAN STARTS FINE WHEN I TRY TO ACCELERATE THE QUAD BOGS FEELS LIKE ITS GOING TO STALL BUT THEN GOES BUT NOT AT FULL POWER AFTER RELEASING GAS THERE IS A LOUD BACKFIRE ...


carbon on the plugs indicates flooding
the backfire indicates fuel being ignited in the exhaust
have the carby /fuel system professionally overhauled

May 27, 2017 | Polaris ATV

1 Answer

Help 07 polaris 500 sportsman 500ho cranks but will not start backfires only. changed gas cleaned carb cleaned fuelpump new filter 80 lbs compression new plug.points under thottle leaver has gap can not...


All most positive it is in your carb take the bowl off it as you take it off there is a small tube that hangs down that all most reaches the bottom of the bowl need to take a small wire and push through it it is blocked .symptoms backfiring no idle coughing and sputtering if it does start

Feb 05, 2018 | Polaris ATV

1 Answer

Engine won't run properly


sounds like its running rich. check your float height and then lower your main jet needle a notch

Dec 04, 2017 | Polaris ATV

Not finding what you are looking for?
Polaris ATV Logo

Related Topics:

2,592 people viewed this question

Ask a Question

Usually answered in minutes!

Top Polaris ATVs Experts

john h

Level 3 Expert

16397 Answers

Matt Olenzek
Matt Olenzek

Level 2 Expert

297 Answers

Wade Mobley
Wade Mobley

Level 3 Expert

513 Answers

Are you a Polaris ATV Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...