Question about Polaris ATV

Open Question

93 300 polaris sportsman 4x4 does not engage on high or reverse

Only the low gear that work no reverse and no high gear

Posted by Anonymous on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 2 Answers

SOURCE: 2004 polaris 700 sportsman. the 4x4 will only

i have seen this problem several times you have gotten water in your front diff it has an electro magnet engagment and rust on the rollers will cause intermittent problems take it apart clean or replace rollers and cage

Posted on Apr 27, 2009

  • 1 Answer

SOURCE: 2002 Polaris Sportsman 700: AWD Not Engaging

ok i have a 335 that had a similiar problem 4 wheel drive would not engage and speedometer acted like it was a tach when started in an idol..... i replaced the battery and believe the condition was caused by low voltage if your battery is is not very good your machine wont generate enough voltage for your 4 wheel drive to engage....try it maybe this will help...

Posted on Aug 09, 2009

  • 2 Answers

SOURCE: 2005 Polaris 700 sportsman 4x4 gets warm, looses power?

My 2005 700 efi is doing the same thing. So far I have found that the engine and exhaust get so hot that the fuel starts to boil and causes the fuel pump to vapor lock. I taped up the tank with some reflective tape/insulator stuff and now I'm trying to figure out why its running so hot.(The exhaust manifold glows red hot) I've cleaned the radiator and flushed the system. I just need to check the water pump and thermostat. Any other suggestions?

Posted on Sep 02, 2009

  • 2 Answers

SOURCE: polaris 500 sportmans and the 4x4 does not work in reverse

On mine the override button has to be pushed

Posted on Jan 09, 2010

  • 1 Answer

SOURCE: 03 Polaris sportsman 700 4x4 will not Disengage

I KNOW THAT IF YOU HAVENT CHANGED THE HUB OIL IN A WHILE THAT IT GETS DIRTY AND GETS STUCK IN 4-WHEEL

Posted on Jan 25, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2002 Polaris Sportsman 700 vtwin. Why doesn't 4x4 work?


not sure about that model but other polari I've worked on use electronic hubs to engage the four wheel drive. check the wiring to the hubs or possibly a bad switch.

Mar 23, 2016 | ATVs

1 Answer

The 4x4 isnt working on my 2010 polaris sportsman 500 ho.


Tony, sounds like a transfer case issue, have machine checked or scanned for error codes.
Check the attached links,Manuals and guides, Good luck with your Bike
"I hope this helped you out, if so let me know by pressing the helpful button. Check out some of my other posts if you need more tips and info."

ATV TROUBLESHOOTING AND MAINTENANCE
How to Diagnose Motorcycle Electrical Problems Dennis Kirk Inc
Service Manuals for Download in PDF

Mar 04, 2016 | Polaris 2010 Sportsman 500 H.O

2 Answers

Tranny works, shifter wont shift the gears. how to fix?


My 2005 Polaris ATP 500 requires I depress the right foot brake while shifting into reverse or down into low range. Perhaps some adjustment on the foot brake to make this work. Also check linkage to make sure it is not binding. Others say if the idle speed is too high, you may not be able to shift. Try shifting with the engine off to see if it goes into the gears, using the foot brake. If yes, try again while at low idle speed.

Mar 25, 2015 | Polaris 2004 Sportsman 500 H.O

1 Answer

2009 polaris 850 sportsman, reverse will not work.


put some grease in the tranny, and while your at it check th back diff too, by just loosening the pumpkin bolt and sticking your finger in there to see if there is enough 75/90, if not just ADD TO THE PUMPKIN till it reaches the top of the bolt hole while the unit is sitting on its 4 wheels it should just be spilling out at the threads put bolt back in and hand tighten then snug but not too tight, tht should do it.

Mar 31, 2014 | Polaris 2009 Sportsman 850 EFI XP With EPS

2 Answers

1996 polaris sportsman 4*4 wont shift


You can try to adjust the linkage below the shifter should be 2 rods there one is low gear other is forward and backwards if that's doesn't do it then you have to pull trans out and sleeve the shift heads hope you can just adjust it

Feb 10, 2014 | RTO 200cc Full Size Four Wheeler ATV

1 Answer

2008 polaris 800 sportsman touring wont engage in 4x4 high without holding in the override button


try this first right beside the reverse button u will see 2 sets of wires clipped into the control be careful and pull these 2 apart u will see they will be all corroded up clean them up and dielectric them see if that works its a easy fix maybe

if that doesnt work try this...

I replaced the speed sensor, got my speedo operation back, no more intermittent 4x4 issues, and no more stalling in reverse! It's actually quite annoying how many things are tied into that one sensor. Makes for a frustrating trip out of the bush if it starts acting up on the trail (like mine did). Good luck with your repairs!

Jan 04, 2014 | Polaris 2008 Sportsman 800 EFI

1 Answer

When my 2012 polaris sportsman 800 is in gear and i press the accelerater it dose not move. I tried putting it into high, low, and reverse and press the accelerater it dose not move. The primare and the...


If you have a primary and secondary clutch, and your ATV still fails to move with proof that they are working, my best advice would be to check the pilot shaft and the gears for excessive wear. Even in new products, the case of excessive wear can be well known, and it would be wise to take it back to the dealer if you continue to have the problem.

Nov 05, 2013 | Polaris 2012 Sportsman 800 EFI

Not finding what you are looking for?
Polaris ATV Logo

Related Topics:

28 people viewed this question

Ask a Question

Usually answered in minutes!

Top Polaris ATVs Experts

john h

Level 3 Expert

12104 Answers

Matt Olenzek
Matt Olenzek

Level 2 Expert

293 Answers

yadayada
yadayada

Level 3 Expert

75797 Answers

Are you a Polaris ATV Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...